|

NTSB Safety Recommendations A-10-44 and -45

The National Transportation Safety Board recommends that the
Federal Aviation Administration:

Require repetitive inspections for fatigue cracking of the
nose landing gear actuator attachment foot areas on all
Piper PA-46-310 and -350P engine mounts and require
replacement, if necessary. (A-10-44)

Require Piper to redesign the PA-46-310 and -350P engine
mounts so that they are not susceptible to fatigue cracking
in the attachment foot areas. (A-10-45)

The National Transportation Safety Board (NTSB) has investigated two accidents involving Piper PA-46-350P airplanes that resulted from fatigue cracking in the attachment between the nose landing gear (NLG) actuator and the engine mount. Such fatigue cracks can lead to the collapse of the NLG, which could cause a serious or catastrophic accident if the separation occurred at a critical point during takeoff or landing or if the aircraft collided with parked aircraft or aircraft waiting at taxiways.

On August 16, 2009, about 1130 eastern daylight time,1 a Piper PA-46-350P, N548C, experienced an NLG collapse during landing at the Orlando-Sanford International Airport, Sanford, Florida.2 The private pilot and passenger were uninjured, and the airplane sustained substantial damage. No flight plan was filed for the 14 Code of Federal Regulations (CFR) Part 91 personal flight, nor was one required to be filed by the Federal Aviation Administration (FAA). Visual meteorological conditions (VMC) prevailed at the time of the accident.

On May 19, 2007, about 1305, a Piper PA-46-350P, N411MD, experienced an NLG collapse during landing at the Indianapolis Metropolitan Airport near Fishers, Indiana.3 The pilot and passenger were uninjured, and the airplane sustained substantial damage. No flight plan was filed for the 14 CFR Part 91 personal flight, nor was one required to be filed by the FAA. VMC prevailed at the time of the accident.

The NLG actuator on Piper PA-46-350P airplanes is bolted via two attachment feet to the lower aft engine mount, which is constructed of welded tubes (see figure 1). The NLG actuator extends down and forward from the attachment feet and attaches to the NLG. During taxi, takeoff, and landing, the attachment feet transmit loads from the NLG to the engine mount, thus creating repetitive tensile stress in the engine mount attachment feet areas and, in some cases, leading to fatigue cracking.

Piper PA-46-310 and -350P airplanes have either an original engine mount or a redesigned engine mount (see figure 2).5 In the original design, each attachment foot is a two-piece part consisting of a metal disk welded to the end of a metal tube, which is then welded to the engine mount support tubes. In the redesigned engine mount, each attachment foot is a one-piece machined part made from a single piece of steel, eliminating the welding within the feet themselves. However, on both the original and redesigned engine mounts, the attachment feet are welded to the engine mount support tubes, which is where fatigue cracking has been identified by the NTSB.

The airplane in the Sanford, Florida, accident was equipped with a redesigned engine mount that was installed at the time of manufacture. The NTSB’s postaccident examination of N548C revealed that the right attachment foot had fractured at the engine mount support tube. The NTSB materials laboratory’s examination of the fractured foot revealed a fatigue crack emanating from multiple origins at the exterior of the joint where the attachment foot was welded to the support tube. At the time of the accident, the airplane was 8 years old and had accumulated 711 flight hours with 878 cycles since new (CSN).

The airplane in the Fishers, Indiana, accident had a redesigned engine mount that was installed on March 21, 2003. The airplane had accumulated 542 flight hours and an estimated 1,400 cycles since then. At the time of the accident, the airplane was 7 years old and had accumulated a total of 772 flight hours.6 The NTSB’s postaccident examination of N411MD revealed that the right attachment foot had separated from the rest of the engine mount due to fatigue cracking7 where the attachment foot was welded to the support tube.
The NTSB also notes that a similar incident of fatigue cracking of an NLG attachment foot was found on September 29, 2009, during a routine inspection of a Piper PA-46-350P airplane. The airplane was 5 years old and had accumulated a total of 678 flight hours with 600 CSN and was equipped with the redesigned engine mount.

On April 22, 2002, Piper issued mandatory Service Bulletin (SB) 1103, recommending that operators of PA-46-310P, -350P, and -500TP8 airplanes inspect the NLG actuator attachment foot area of the original engine mounts for evidence of fatigue cracking. The SB indicated that such cracking had been found in this area of some original engine mounts.

The inspection included visual and liquid penetrant inspection at the next regular scheduled maintenance event and each 100 hours in service or at the annual inspection, whichever occurred first. If cracks were found, the original engine mounts were to be replaced with the redesigned engine mounts before returning to service. SB 1103 does not subject the airplanes with redesigned engine mounts to repetitive inspections, and replacing the original engine mount with the redesigned engine mount relieves the need for repetitive inspections. Piper issued several inspections.

The NTSB is concerned that the redesigned engine mounts on Piper P
A-46-310 and -350P model airplanes have attachment foot areas susceptible to fatigue cracking similar to the fatigue cracks identified by Piper on the original engine mounts. The NTSB concludes that the tensile stresses applied to the redesigned engine mounts could lead to fatigue fractures in the NLG actuator attachment foot areas. However, redesigned engine mounts are not currently subject to the inspection provisions of SB 1103, nor is compliance with SB 1103 required.10 Although the NTSB is not aware of incidents or accidents involving original engine mounts that have not been inspected, the NTSB believes that inspections of the original engine mounts should also be mandatory in order to detect fatigue cracking.

Therefore, the NTSB recommends that the FAA require repetitive inspections for fatigue cracking of the NLG actuator attachment foot areas on all Piper PA-46-310 and -350P engine mounts and require replacement, if necessary.

As previously noted, Piper redesigned the engine mounts on the PA-46-310 and -350P in an effort to prevent fatigue cracking at the attachment foot areas. However, based on the accidents discussed above, this redesign does not appear to have been successful since fatigue cracking has also occurred in the redesigned engine mounts. Therefore, the NTSB recommends that the FAA require Piper to redesign the PA-46-310 and -350P engine mounts so that they are not susceptible to fatigue cracking in the attachment foot areas.
Therefore, the National Transportation Safety Board recommends that the Federal Aviation Administration:

Require repetitive inspections for fatigue cracking of the nose landing gear actuator attachment foot areas on all Piper PA-46-310 and -350P engine mounts and require replacement, if necessary. (A-10-44)

Require Piper to redesign the PA-46-310 and -350P engine mounts so that they are not susceptible to fatigue cracking in the attachment foot areas. (A-10-45)

In response to the recommendations in this letter, please refer to Safety Recommendations A-10-44 and -45. If you would like to submit your response electronically rather than in hard copy, you may send it to the following e-mail address: correspondence@ntsb.gov.

To include the featured image in your Twitter Card, please tap or click their icon a second time.

Similar Posts

  • | |

    Aviation Dominoes

    Jet Airways is suspending its Mumbai and Johannesburg route, leaving the field open for South African Airways, which is increasing flights between those cities by an additional weekly flight, beginning June 16th.

    However, other sources report that South African Airways is canceling direct flights between London and Cape Town. Will British Airways and Emirates be filling in the gap?

    Business Day asks if Cape Town can realise the dream of using its global location to take advantage of growing international trade. Cape Town International is South Africa’s second-largest airport and was named Africa’s leading airport in the 2012 World Airport Awards.

    To include the featured image in your Twitter Card, please tap or click their icon a second time.
  • |

    NTSB SENDING TEAM TO ASSIST GOVERNMENT OF LIBYA IN AVIATION ACCIDENT INVESTIGATION

    The National Transportation Safety Board is dispatching a team of investigators to assist the government of Libya in its investigation of an accident involving an Airbus A330-200, which was equipped with General Electric CF6-8E1
    engines. At approximately 6:00 am local time on May 12, 2010, the aircraft, operated by Afriqiyah Airways, crashed on approach to Tripoli airport in Tripoli, Libya. Of the 104 passengers and crew on board the airplane, there was one
    survivor. The airplane originated in Johannesburg, South Africa.

    As the State of design and manufacture for the engines, NTSB Chairman Deborah A.P. Hersman has designated Senior Air Safety Investigator, Lorenda Ward, as the U.S. Accredited Representative. The U.S. team will also include an NTSB engines specialist as well as technical advisors from the Federal Aviation Administration, and General Electric. The team is expected to arrive tomorrow afternoon.

    The Bureau d’Enquete et d’Analyse (BEA) of France, representing the country of manufacture of the airplane, has also sent a team of investigators to Libya.

    The investigation is being conducted by the Libyan Civil Aviation Authority, which will release all information on the progress of the investigation.

    To include the featured image in your Twitter Card, please tap or click their icon a second time.
  • |

    NTSB ISSUES RECOMMENDATIONS DEALING WITH EMERGENCY LOCATOR TRANSMITTERS IN GENERAL AVIATION AIRCRAFT FOLLOWING CRASH INVOLVING SENATOR STEVENS

    FOR IMMEDIATE RELEASE: January 5, 2011
    SB-11-02

    The National Transportation Safety Board today issued two safety recommendations to the Federal Aviation Administration requiring a detailed inspection of all emergency locator transmitters (ELT) installed on general aviation aircraft to ensure that their mountings maintain their retention capabilities during an accident sequence.

    An ELT is designed to broadcast a signal through an externally mounted antenna that contains the aircraft’s registration information and the global positioning system coordinates of the original signal. Also, the “homing signal” can be detected locally by other aircraft, air traffic control facilities, or rescue personnel who use a compatible receiver.

    “In this case, the airplane was equipped with a functioning 406 megahertz ELT, which can be a tremendous aid to search and rescue operations,” said NTSB Chairman Deborah A.P. Hersman. “But this vital life-saving technology won’t do anyone any good if it doesn’t stay connected to the antenna.”

    On August 9, 2010, a de Havilland turbine Otter airplane crashed in mountainous tree-covered terrain approximately 10 miles from Aleknagik, Alaska. Nearly five hours after the crash, volunteer airborne search personnel located the aircraft approximately 19 miles from where the flight originated. The pilot and four passengers, including former U.S. Senator Ted Stevens, sustained fatal injuries. The other four passengers were seriously injured.

    Aircraft involved in the search and rescue efforts and satellites did not detect any ELT signals. Following the discovery of the airplane, a pararescuer found the ELT loose on the floor of the airplane. The ELT had activated but had separated from its mounting bracket and antenna.

    To include the featured image in your Twitter Card, please tap or click their icon a second time.

  • Is the Q400 Safe?

    When looking at track records, the biggest question of safety in the Bombardier Q400 seems to be the failure of the landing gear to retract. Airworthiness directives in the archives refer to this issue as “fatigue failure of the nose landing gear electrical harness” although when gear retraction failed in 2007 on a Scandinavian Airlines plane, the cause of the failure was described as “hydraulics actuator top eyebolt was separated from the actuator.”

    Of course in the Buffalo Crash, the landing gear issue did not come into play.

    Significant icing may have been THE problem. It may have been icing that crippled the plane, period. It may have been a salvageable situation. It may have been a crisis situation that nine out of ten pilots could have handled–or 1 in 100.

    Or it may have been one of several factors.

    The Buffalo flight apparently slowed enough to lose lift.

    When the stall-warning system angled the plane’s nose down to regain speed, instead of following the proper procedure–lowering the nose to get out of a stall–the captain pulled back on the controls and added power.

    Pilot training is being discussed as a factor in the crash. Or was it as James Fallows postulates a “tailplane stall?”

    Nasa Tailplane Stall Video

    However speculation is simply a logical exercise. The NTSB investigation is ongoing as the FBI, NTSB, and FAA examine the flight data and the world waits for an answer.

    To include the featured image in your Twitter Card, please tap or click their icon a second time.
  • |

    EU Banned List updated: Official Press Release

    Commission updates the list of airlines banned from the European airspace
    The European Commission has adopted the thirteenth update of the Community’s list of airlines banned in the European Union to include all air carriers of two additional countries: Sudan and the Philippines, on the basis of safety assessments by the International Civil Aviation Organization (ICAO). With this update, restrictions placed on Air Koryo from the Democratic People’s Republic of Korea and TAAG from Angola are partially lifted under certain conditions, while the operations of Iran Air will be restricted.

    Commission Vice-President Siim Kallas, responsible for Transport, said: “Safety comes first. We are ready to support countries that need to build up technical and administrative capacity to guarantee the necessary standards in civil aviation. But we cannot accept that airlines fly into the EU if they do not fully comply with international safety standards.”

    With this update, the Air Koryo licensed in the Democratic People’s Republic of Korea, subject to an operating ban since March 2006, is allowed to resume operations into the EU with two aircraft which are fitted with the necessary equipment to comply with mandatory international standards and following appropriate oversight by its authority. The rest of its fleet remains barred from operating into the EU.

    The Commission recognises the improvements in the operations of TAAG Angola Airlines by allowing the air carrier to operate under certain strict conditions with specific aircraft to all destinations in the EU, not only to Lisbon.

    The civil aviation authority of Angola is urged to intensify its oversight in relation to all carriers and continue the recertification of the other Angolan air carriers which remain banned from operating into the EU.

    The Commission imposes an operating ban on all operations of Sudanese air carriers, due to a poor safety performance of the civil aviation authority of Sudan resulting from persistent non-compliance with international standards in the area of oversight.

    The Commission acknowledges the recent efforts launched by the competent authorities to reform the civil aviation system in the Philippines and steps taken to address safety deficiencies reported by the FAA and ICAO and measures taken by two carriers – Philippines Airlines and Cebu Airlines – to ensure safety of operations. It is ready to support the Philippines to overcome serious safety deficiencies.

    In view of the significant safety concerns identified by ICAO in relation to the authorities, the Commission with the unanimous support of the Air Safety Committee is forced to follow the principle of precaution and impose an operating ban on all air carriers licensed in the Philippines. The Commission is ready to support the Philippine authorities and conduct a visit to the country.

    Following an examination of the safety of Iran Air’s operations into the EU through ramp checks of its aircraft in the Community, evidence of serious incidents and accidents suffered by the carrier and insufficient oversight from the authority over the past year, the Air Safety Committee concluded unanimously that the operations of Iran Air to the EU should be restricted. The carrier will only be allowed to use certain aircraft for flights to Europe. The Commission will visit Iran over the next months to verify the oversight of the Iranian civil aviation organisation and the safety situation of Iran Air.

    The results of a recent visit by the European Aviation Safety Agency to Albania indicate that the competent authority needs to strengthen its capabilities to ensure the oversight of the air carriers it licences. The authorities have been urged by the Commission to take prompt action to address these issues. The Commission will closely monitor the situation.

    The Commission follows closely the performance of Egyptian air carriers. A visit to Egypt to verify the oversight functions of the civil aviation authority and the performance of certain air carriers showed that this authority is carrying out its responsibilities correctly. The Commission will continue to cooperate closely with this authority to ensure that proposed improvements can be implemented.

    Today, the Community’s list has three carriers whose operations are fully banned in the European Union – Ariana Afghan Airlines from Afghanistan, Siem reap Airways International from Cambodia and Silverback Cargo Freighters from Rwanda.

    All carriers from 17 countries – 278 companies in total – are banned: Angola, Benin, the Democratic Republic of Congo, Djibouti, Equatorial Guinea, Gabon, (with the exception of three carriers which operate under restrictions and conditions), Indonesia, Kazakhstan (with the exception of one carrier which operates under restrictions and conditions), the Kyrgyz Republic, Liberia, Philippines, Republic of Congo, Sierra Leone, Sao Tome and Principe, Sudan, Swaziland and Zambia. 10 air carriers are allowed to operate under restrictions and conditions – Air Koryo from the Democratic People Republic of Korea, TAAG Angola Airlines, Air Astana from Kazakhstan, Iran Air from Iran Gabon Airlines, Afrijet and SN2AG from Gabon, Air Bangladesh, Air Service Comores and Ukrainian Mediterranean Airlines from Ukraine.

    To include the featured image in your Twitter Card, please tap or click their icon a second time.
  • | | | |

    Sleeping Pilots

    Two pilots fell asleep while flying an Airbus A330, and then tattled on themselves, blaming 5 hours sleep the night before.

    Pilots are allowed naps but not at the same time. The British airline has not been identified, nor have the pilots’ names been released.

    To include the featured image in your Twitter Card, please tap or click their icon a second time.